Toyota Corolla Cross Owners & Service Manuals

Toyota Corolla Cross: Lost Communication with Front Right Air Mix Damper Control Servo Motor LIN Missing Message (B145A87)

Toyota Corolla Cross (2022-2024) Service Manual / Vehicle Interior / Heating / Air Conditioning / Air Conditioning System (for Hev Model) / Lost Communication with Front Right Air Mix Damper Control Servo Motor LIN Missing Message (B145A87)

DESCRIPTION

The air conditioning harness assembly connects the air conditioning amplifier assembly and the No. 1 air conditioning radiator damper servo sub-assembly. The air conditioning amplifier assembly supplies power and sends operation instructions to No. 1 air conditioning radiator damper servo sub-assembly through the air conditioning harness assembly. The No. 1 air conditioning radiator damper servo sub-assembly sends pulse signals to inform the air conditioning amplifier assembly of the damper position.

DTC No.

Detection Item

DTC Detection Condition

Trouble Area

Memory

B145A87

Lost Communication with Front Right Air Mix Damper Control Servo Motor LIN Missing Message

Diagnosis Condition:

  • Ignition switch ON

Malfunction Status:

  • Error or lost communication with No. 1 air conditioning radiator damper servo sub-assembly

Detection Time:

  • Continuously for 10 seconds or more

No. 1 air conditioning radiator damper servo sub-assembly

Memorized
DTC Detection Condition Combination Table
 

Vehicle Condition

Pattern 1

Pattern 2

Diagnosis Condition

Ignition switch ON

○

○

Malfunction

Error communication with No. 1 air conditioning radiator damper servo sub-assembly

○

-

Lost communication with No. 1 air conditioning radiator damper servo sub-assembly

-

○

Detection Time

Continuously for 10 seconds or more

Continuously for 10 seconds or more

Trip Count

1 trip

1 trip

HINT:

If the conditions of either of these patterns are detected, a DTC will be stored

WIRING DIAGRAM

PROCEDURE

1.

CHECK FOR DTC

(a) Check for DTCs.

Body Electrical > Air Conditioner > Trouble Codes

Result

Proceed to

B142A88 is output

A

B142A88 is not output

B
A

GO TO DTC B142A88

B

REPLACE NO. 1 AIR CONDITIONING RADIATOR DAMPER SERVO SUB-ASSEMBLY

    READ NEXT:

     Front Right Air Mix Damper Control Servo Motor Actuator Stuck Off (B145B7F)

    DESCRIPTION The No. 1 air conditioning radiator damper servo sub-assembly sends pulse signals to inform the air conditioning amplifier assembly of the damper position. The air conditioning amplifier a

     A/C Inverter High Voltage Power Resource Circuit Voltage Out of Range (B14711C)

    DESCRIPTION The hybrid vehicle control ECU monitors the voltage of the HV battery. The hybrid vehicle control ECU stops compressor control and stores this DTC when the monitored voltage is outside the

     A/C Inverter High Voltage Output Circuit Voltage Out of Range (B14721C)

    DESCRIPTION The inverter in the compressor with motor assembly outputs high-voltage electricity to operate the motor. If there is an open or short in the output circuit, the hybrid vehicle control ECU

    SEE MORE:

     Inspection

    INSPECTION PROCEDURE 1. INSPECT BACK DOOR LOCK WITH COURTESY LIGHT SWITCH (w/o Power Back Door) (a) Check the operation of the door lock motor. (1) Move the back door lock with courtesy light switch assembly to the lock position. (2) Apply auxiliary battery voltage to the back door lock wit

     Rear Differential Side Gear Shaft Oil Seal

    Components COMPONENTS ILLUSTRATION *1 REAR DRIVE SHAFT OIL SEAL - - ● Non-reusable part MP grease Replacement REPLACEMENT CAUTION / NOTICE / HINT The necessary procedures (adjustment,

    © 2020-2024 Copyright www.tcorollacross.com